Trinidad and Tobago and Monthly Production Target

Exercise Chapter 1 Assignment 1 Application 14 Refer to figure 1. 4 on rogue 12 of your text. Use this figure to rate each of the fol ruggeding scenarios. go into beside each scenario your choice (a, b, c, d) and explain fully your choice. High in strength and higher(prenominal) in efficiency high in effectiveness and low in efficiency low in effectiveness and high in efficiency low in effectiveness and low in efficiencyScenario 1 The Production Manager of Moms Cookies had a monthly production intent of 100,000 bags of cookies. His target for quality inspectors is to have the reject rate less than 2% of production. some(prenominal) these targets were met for August. Labor costs are up 5% because overtime had to be incurred to complete some orders,Both goals were met plainly unfortunately labor costs went up. Scenario 2 The reject rate for Moms Cookies was 8% this month. The normal target is less than 2%.The problem was traced too poorly maintained oven which burnt a cast of batches before the problem was rectified. Addition costs were incurred to fix the equipment problem as well as extra costs associated with the Ingredients to make the replacement batches. The caller-out however did make their monthly target of 100,000 bags of cookies. B,The familiarity wasted resources but however they did reach their monthly goals which was 100,000 bag of cookies. Scenario 3 The month displace reports for Moms Cookies have Just been received by the ProductionManager. They show that during the month of September, the company product 101 ,050 bags of cookies. The reject rate was 1%. Labor and sensitive materials were within budgeted levels. No breakdown of equipment occurred. A,Goals were achieved no breakdown of the equipment,no wasted resources and high productivity. Scenario 4 to be hired. There was not enough time to chink these people and projection levels suffered. Only 95,080 bags of cookies were produced this month. The reject rate was 1. 9%.Labor and p iercing materials were within budgeted levels. C,There was no wasted products but goals were not achieved. Scenario 5 Moms cookies imports their coffee bean chips from Trinidad and Tobago. Unfortunately their dollar mark has increased in value against the Canadian dollar which has driven up chocolate costs by 10%. In addition, flatulency prices have gone up and the company uses gas ovens and gas heating. This has added another 5% to the companys expenses. The reject rate was 1. 8% and the company produced 100,200 bags of cookies.